中国科学院机构知识库网格
Chinese Academy of Sciences Institutional Repositories Grid
Quantifying Macroscopic Friction of Diamond-like Carbon Films by Microscopic Adsorption and Removal of Water Molecules

文献类型:期刊论文

作者Wang, Jingjing1,2; Shang LL(尚伦霖)1; Li X(李霞)1; Lu ZB(鲁志斌)1; Zhang GA(张广安)1; Lu ZB(鲁志斌); Zhang GA(张广安)
刊名Langmuir
出版日期2018
卷号34期号:1页码:58-65
ISSN号0743-7463
DOI10.1021/acs.langmuir.7b02613
英文摘要

The adsorption and desorption of water molecules, which affect the physical and chemical properties of the sliding interface, are critical for the friction behaviors of two solid contacts in atmosphere environment. The amount of water adsorbed on the open surface is a function of gas pressure according to an adsorption equation. However, for a confined sliding interface, the variation of surface fraction covered by gas molecules with water vapor pressure and its induced effects on friction have not been figured out. In this work, the macroscopic friction of diamond-like carbon (DLC) films in a water vapor atmosphere is quantified on the basis of microscopic adsorption and removal of water molecules. The studies correlate the fraction of water molecules adsorbed on the interface of self-mated DLC films with water vapor pressure to illustrate the direct relationship between friction coefficient and gas pressure by first-principles calculations and model fitting. The calculated results revealed that chemisorption and physisorption of water molecules occur on the surfaces of hydrogen-free DLC films (ta-C) and hydrogenated DLC films (HCF). Then, the relation between friction and gas pressure was built by employing a fractional coverage model based on the linear adsorption equation and gas removal. The obtained model agrees well with the typical experimental results about the steady-state friction coefficient of both highly hydrogenated DLC film (HCF) and tetrahedral amorphous carbon (ta-C) film during sliding at various water vapor pressures. In addition, it gave the curves of fractional surface coverage as a function of water vapor pressure. These results show that the frictional coefficient of DLC films could be predicted on the basis of fractional surface coverage as well as the intrinsic characters on surface chemistry. We suggest that the model may be thus extended to understand and predict the friction of DLC films under a specific gas pressure at a low load and speed.

学科主题材料科学与物理化学
资助项目低维材料摩擦学研究组
语种英语
WOS记录号WOS:000422611500008
资助机构National Natural Science Foundation of China (Grant 51775535 ; 51405476) ; Key Program of the Chinese Academy of Sciences (QYZDY-SSW-JSC009)
源URL[http://210.77.64.217/handle/362003/23775]  
专题兰州化学物理研究所_固体润滑国家重点实验室
通讯作者Lu ZB(鲁志斌); Zhang GA(张广安)
作者单位1.Chinese Acad Sci, State Key Lab Solid Lubricat, Lanzhou Inst Chem Phys, Lanzhou 730000, Gansu, Peoples R China
2.Univ Chinese Acad Sci, Beijing 100039, Peoples R China
推荐引用方式
GB/T 7714
Wang, Jingjing,Shang LL,Li X,et al. Quantifying Macroscopic Friction of Diamond-like Carbon Films by Microscopic Adsorption and Removal of Water Molecules[J]. Langmuir,2018,34(1):58-65.
APA Wang, Jingjing.,Shang LL.,Li X.,Lu ZB.,Zhang GA.,...&Zhang GA.(2018).Quantifying Macroscopic Friction of Diamond-like Carbon Films by Microscopic Adsorption and Removal of Water Molecules.Langmuir,34(1),58-65.
MLA Wang, Jingjing,et al."Quantifying Macroscopic Friction of Diamond-like Carbon Films by Microscopic Adsorption and Removal of Water Molecules".Langmuir 34.1(2018):58-65.

入库方式: OAI收割

来源:兰州化学物理研究所

浏览0
下载0
收藏0
其他版本

除非特别说明,本系统中所有内容都受版权保护,并保留所有权利。