"isomeric effect" on the crystallization behavior of polyimide from odpa and oda
文献类型：期刊论文
| 作者 | Zhang Min1,2; Zhao Guiyan1,2; Wang Zhen1; Jiang Wei1; Gao Lianxun1; Ding Mengxian1 |
| 刊名 | Acta polymerica sinica
 |
| 出版日期 | 2008-03-01 |
| 期号 | 3页码:251-258 |
| 关键词 | Polyimides Crystallization Isomeric dianhydride Isomers |
| ISSN号 | 1000-3304 |
| 通讯作者 | Zhang min() |
| 英文摘要 | The isomeric effects of dianhydride on the crystalline properties of polyimide were reported, it was a continuation of isomeric polyimides studies in our group. a series of molecular-weight-controlled isomeric polyimides powders based on three dianhydride isomers, 3, 3', 4, 4'-oxydiphthalic dianhydride (4, 4'-odpa), 2, 3', 3, 4'-oxydiphthalic dianhydride (3, 4'-odpa) and 2, 2', 3, 3'-oxydiphthalic dianhydride (3, 3'-odpa), and 4, 4'-oxydianiline (oda) were prepared by traditional two-step method in dmac, and phthalic anhydride (pa) was used as end-capper. wide-angle x-ray diffraction (waxd) and differential scanning calorimetry (dsc) were used to investigate the crystallization behavior of isomeric polyimides. the annealing temperature, annealing time, external force shearing and molecular weight effects on the crystallization of isomeric polyimides were studied. the results proved that 4, 4'-odpa/oda-based polyimide powder was amorphous at room temperature and could crystallize during annealing or shearing process above t-g. the crystallization of 4, 4'-odpa/oda-based polyimide was enhanced by increasing the annealing temperature and time, decreasing molecular weight or pushing shearing above tg two melting endo-peaks appeared evidently when the annealing temperature was below 300 degrees c the two melting peaks tended to be close to each other with the increase of annealing temperature, and only one melting peak was found when annealing temperature reached 370 degrees c. the higher melting temperature of 4,4'-odpa/oda-based polyimide was aroud 370 similar to 380 degrees c, however, this polyimide was difficult to recrystallize once melted. this polyimide was annealed at 370 degrees c for different times, the amorphous as-prepared samples had crystallized after annealing at 370 degrees c only in 1 min, besides the crystallinity was increased with the increase of the annealing time, but no crystalline form change was found. the polyimide with low molecular weight was easy to crystallize. it can be seen that the polyimide with eta(inh) of 0.34 dl/g showed the highest endo-peak, the polyimide with the eta(inh) of 0.64 dl/g showed the smallest endo-peak. while the polyimide with the eta(inh) of 1.1 dl/g exhibited completely amorphous. pushing shearing at 250,260 and 300 degrees c for 100 min with a shear rate of 2 s(-1) indicated that the shearing process indeed enhanced the crystallization of polyimide above 260 degrees c, although the effect was not so obvious. while at 250 degrees c or lower temperatures the shearing almost did not effect at all. the isomeric polyimides based on 3, 4'-odpa/oda and 3, 3'-odpa/oda were synthesized with the comparable inherent viscosity with 4, 4'-odpa/oda. they were tested after the same treatment as we had did for 4, 4'-odpa/oda, such as different annealing temperature, annealing time, shearing, etc., however, the two isomeric polyimides just as expected remained amorphous. |
| WOS关键词 | DIANHYDRIDE 1,3-BIS(4-AMINOPHENOXY)BENZENE 1,12-DODECANEDIAMINE ; SEMICRYSTALLINE POLYIMIDES ; AROMATIC POLYIMIDE ; THERMAL-STABILITY ; GLASS-TRANSITION ; MORPHOLOGY ; HOMOPOLYIMIDES ; TPI |
| WOS研究方向 | Polymer Science |
| WOS类目 | Polymer Science |
| 语种 | 英语 |
| WOS记录号 | WOS:000254640400008 |
| 出版者 | SCIENCE CHINA PRESS |
| URI标识 | http://www.irgrid.ac.cn/handle/1471x/2387822 |
| 专题 | 中国科学院大学 |
| 通讯作者 | Zhang Min |
| 作者单位 | 1.Chinese Acad Sci, Changchun Inst Appl Chem, State Key Lab Polymer Phys & Chem, Changchun 130022, Peoples R China 2.Chinese Acad Sci, Grad Sch, Beijing 100049, Peoples R China |
| 推荐引用方式 GB/T 7714 | Zhang Min,Zhao Guiyan,Wang Zhen,et al. "isomeric effect" on the crystallization behavior of polyimide from odpa and oda[J]. Acta polymerica sinica,2008(3):251-258. |
| APA | Zhang Min,Zhao Guiyan,Wang Zhen,Jiang Wei,Gao Lianxun,&Ding Mengxian.(2008)."isomeric effect" on the crystallization behavior of polyimide from odpa and oda.Acta polymerica sinica(3),251-258. |
| MLA | Zhang Min,et al.""isomeric effect" on the crystallization behavior of polyimide from odpa and oda".Acta polymerica sinica .3(2008):251-258. |
入库方式： iSwitch采集
来源：中国科学院大学
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。