Self-Lubricating Ultrahigh Molecular Weight Polyethylene Thin Films with Excellent Wear Resistance at Light Friction Loads on Glass and Silicon
文献类型：期刊论文
| 作者 | Wang, Hongling1; Wang, Yunxia2; Su, Qiong1; Wang, Yanbin1; Sun, Chufeng1; Wang, Aijun1 |
| 刊名 | JOURNAL OF MACROMOLECULAR SCIENCE PART B-PHYSICS
 |
| 出版日期 | 2019-02-01 |
| 卷号 | 58期号:2页码:317-329 |
| 关键词 | Ultrahigh molecular weight polyethylene thin films self-lubrication tribological reciprocation wear mechanism |
| ISSN号 | 0022-2348 |
| DOI | 10.1080/00222348.2019.1565155 |
| 通讯作者 | Wang, Yunxia(yunxiawang@licp.cas.cn) ; Su, Qiong(hgsq@xbmu.edu.cn) |
| 英文摘要 | Thin films of ultrahigh molecular weight polyethylene (UHMWPE) were prepared on glass and silicon using a dip-coating technique, followed by removal of the decahydronaphthalene solvent at 140 degrees C for 20 hours and cooling in the oven in air. The wetting ability of the films was investigated by a contact angle method. The tribological behavior of the films was investigated using a ball-on-disk configuration in reciprocating mode. The reciprocating frequency of 4 Hz and single sliding distance of 5 mm used corresponded to a sliding speed of 40 mm/s. The counterface was a GCr15 steel ball with diameter of 3 mm and the normal frictional loads were 10-300 g. The worn surfaces on the films and wear scars on the steel ball were observed and analyzed by scanning electron microscopy (SEM). It was found that the surface morphologies of the films on glass and silicon were different, which is ascribed to the difference in thermal conductivity of the glass and silicon. Evaporation of the solution caused micro-orifices in the films on glass. The water contacting angle of about 87 degrees on the films on the two substrates was similar to that of bulk UHMWPE. Their friction coefficient of about 0.1-0.2 indicated the films were self-lubricating. The wear life of the films decreased quickly with the increase of friction load. At light friction loads, the films showed excellent wear resistance. Extrusion was believed to be the main wear mechanism of the films. |
| 收录类别 | SCI |
| WOS关键词 | UHMWPE ; BEHAVIOR ; FIBERS |
| WOS研究方向 | Polymer Science |
| WOS类目 | Polymer Science |
| 语种 | 英语 |
| WOS记录号 | WOS:000461686100008 |
| 出版者 | TAYLOR & FRANCIS INC |
| URI标识 | http://www.irgrid.ac.cn/handle/1471x/2555538 |
| 专题 | 寒区旱区环境与工程研究所 |
| 通讯作者 | Wang, Yunxia; Su, Qiong |
| 作者单位 | 1.Northwest Minzu Univ, Coll Chem Engn, Key Lab Util Environm Friendly Composites & Bioma, Lanzhou, Gansu, Peoples R China 2.Chinese Acad Sci, Lanzhou Inst Chem Phys, State Key Lab Solid Lubricat, Lanzhou, Gansu, Peoples R China |
| 推荐引用方式 GB/T 7714 | Wang, Hongling,Wang, Yunxia,Su, Qiong,et al. Self-Lubricating Ultrahigh Molecular Weight Polyethylene Thin Films with Excellent Wear Resistance at Light Friction Loads on Glass and Silicon[J]. JOURNAL OF MACROMOLECULAR SCIENCE PART B-PHYSICS,2019,58(2):317-329. |
| APA | Wang, Hongling,Wang, Yunxia,Su, Qiong,Wang, Yanbin,Sun, Chufeng,&Wang, Aijun.(2019).Self-Lubricating Ultrahigh Molecular Weight Polyethylene Thin Films with Excellent Wear Resistance at Light Friction Loads on Glass and Silicon.JOURNAL OF MACROMOLECULAR SCIENCE PART B-PHYSICS,58(2),317-329. |
| MLA | Wang, Hongling,et al."Self-Lubricating Ultrahigh Molecular Weight Polyethylene Thin Films with Excellent Wear Resistance at Light Friction Loads on Glass and Silicon".JOURNAL OF MACROMOLECULAR SCIENCE PART B-PHYSICS 58.2(2019):317-329. |
入库方式： iSwitch采集
来源：寒区旱区环境与工程研究所
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。