A new process combination with high water flux and superior treatment performance for stevia sugar liquor
文献类型：期刊论文
| 作者 | Liu, Hongkai; Graham, Nigel; Liu, Ting; Xue, Xinjie; Yu, Wenzheng
|
| 刊名 | CHEMICAL ENGINEERING JOURNAL
 |
| 出版日期 | 2021-10-01 |
| 卷号 | 421页码:- |
| 关键词 | Stevia Coagulation Membrane fouling PAFC FeSO4 |
| ISSN号 | 1385-8947 |
| 英文摘要 | Stevia sugar is widely used in food owing to its advantages of low calorie content and high sweetness. In the production of stevia sugar, stevia leaves are immersed in water to obtain a crude liquor, which contains many impurities, such as proteins, polysaccharides, organic acids, etc. These impurities are removed typically by coagulation and filtration. At present, suppliers of stevia mainly use a lime + ferrous sulfate (FeSO4) process as the pretreatment, but residual SO2- can cause hydrogen sulfide corrosion and Ca can affect the safety of subsequent boilers in the process. In this study, polyaluminium ferric chloride (PAFC) was evaluated as a superior coagulant to FeSO, together with ultrafiltration (UF) and nanofiltration to remove flocs and other organic contaminants. It was found that coagulation by PAFC out-performed FeSO and was unaffected by pH, while the performance of FeSO was sensitive to pH. At pH 10, FeSO4 had an enhanced coagulation efficiency, but formed soluble Fe2+ complexes with organic substances in the original solution, which adversely affected the quality of the filtrate. Compared with a UF membrane, the NF membrane was more effective in removing contaminants, and more tolerant to membrane fouling. In addition to hydrodynamic flux, measurement of trans-membrane electrical current were used to reflect the severity of membrane fouling. The combination of PAFC as coagulant without pH adjustment, and ultrafiltration, was found to be a simpler and superior treatment for stevia liquor with a high degree of contaminant separation, and avoidance of problems caused by SO and Ca. |
| WOS研究方向 | Engineering, Environmental ; Engineering, Chemical |
| 源URL | [http://ir.rcees.ac.cn/handle/311016/46168]  |
| 专题 | 生态环境研究中心_中国科学院饮用水科学与技术重点实验室 |
| 作者单位 | 1.Chinese Acad Sci, Res Ctr Ecoenvironm Sci, Key Lab Drinking Water Sci & Technol, Beijing 100085, Peoples R China 2.Beijing Inst Technol, Sch Chem & Chem Engn, Beijing 100081, Peoples R China 3.Imperial Coll London, Dept Civil & Environm Engn, London SW7 2AZ, England 4.Dongtai Haorui Biotechnol Co Ltd, Dongtai, Jiangsu, Peoples R China |
| 推荐引用方式 GB/T 7714 | Liu, Hongkai,Graham, Nigel,Liu, Ting,et al. A new process combination with high water flux and superior treatment performance for stevia sugar liquor[J]. CHEMICAL ENGINEERING JOURNAL,2021,421:-. |
| APA | Liu, Hongkai,Graham, Nigel,Liu, Ting,Xue, Xinjie,&Yu, Wenzheng.(2021).A new process combination with high water flux and superior treatment performance for stevia sugar liquor.CHEMICAL ENGINEERING JOURNAL,421,-. |
| MLA | Liu, Hongkai,et al."A new process combination with high water flux and superior treatment performance for stevia sugar liquor".CHEMICAL ENGINEERING JOURNAL 421(2021):-. |
入库方式： OAI收割
来源：生态环境研究中心
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。