Disinfection by-product formation and toxicity evaluation for chlorination with powered activated carbon
文献类型：期刊论文
| 作者 | Huang, Xin ; Yu, Ying; Chen, Huan; Liang, Huikai; Geng, Mengze; Shi, Baoyou
|
| 刊名 | WATER RESEARCH
 |
| 出版日期 | 2021-12-15 |
| 卷号 | 319页码:- |
| ISSN号 | 0959-6526 |
| 关键词 | Hydrazine hydrate waste salt Water washing Waste salt reuse Pyrolysis Ion-exchange membrane electrolysis |
| 英文摘要 | One of the effective reuse application for waste salt, sodium chloride (NaCl), from a near-zero discharge process is the production of sodium hydrate (NaOH) by ion-exchange membrane electrolysis. However, the organic contaminants must be effectively removed from the waste salt before reuse to prevent the rise of cell voltage. In this study, a low-cost near-zero discharge integrated process was proposed for purifying and reusing waste NaCl from the hydrazine hydrate (N2H4) manufacturing process. In the integrated process, water washing followed by activated carbon adsorption was applied to purify the waste salt to meet the requirements for NaOH production using ion-exchange membrane electrolysis. Washing the salt at a water/salt ratio of 5:8, 88.5% of dissolved organic carbon (DOC) was removed, with 25% loss of salt in water washing. Saturated salt solution prepared from the salt after water washing was treated with activated carbon at a dose of 500 mg/L to further remove 10% DOC. Then the salt in the washing wastewater was obtained through evaporation and crystallization and further purified using pyrolysis, with a DOC removal over 99.17% at a temperature >500 degrees C. Evaluation using an ion-exchange membrane electrolysis system running for 42 h showed, that the voltage in treating purified salt by water washing and activated carbon adsorption was almost the same as that for pure salt, suggesting that the substances causing the rise of cell voltage were mostly removed. Meanwhile, though direct pyrolysis exhibited a DOC removal rate as high as 99.29% at a temperature >500 degrees C, the treatment cost is estimated to be 500 RMB/t, while the integrated process treatment cost is estimated to be 224.38 RMB/t. This study proposes a feasible way to reuse the waste salt from N2H4 manufacturing process. |
| 源URL | [https://ir.rcees.ac.cn/handle/311016/46909]  |
| 专题 | 生态环境研究中心_中国科学院饮用水科学与技术重点实验室 |
| 作者单位 | 1.Univ Chinese Acad Sci, Beijing 100049, Peoples R China 2.Chinese Acad Sci, Res Ctr Ecoenvironm Sci, Key Lab Drinking Water Sci & Technol, 18 Shuangqing Rd, Beijing 100085, Peoples R China |
| 推荐引用方式 GB/T 7714 | Huang, Xin,Yu, Ying,Chen, Huan,et al. Disinfection by-product formation and toxicity evaluation for chlorination with powered activated carbon[J]. WATER RESEARCH,2021,319:-. |
| APA | Huang, Xin,Yu, Ying,Chen, Huan,Liang, Huikai,Geng, Mengze,&Shi, Baoyou.(2021).Disinfection by-product formation and toxicity evaluation for chlorination with powered activated carbon.WATER RESEARCH,319,-. |
| MLA | Huang, Xin,et al."Disinfection by-product formation and toxicity evaluation for chlorination with powered activated carbon".WATER RESEARCH 319(2021):-. |
入库方式： OAI收割
来源：生态环境研究中心
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。