Intensification of micromixing efficiency in a ceramic membrane reactor with turbulence promoter
文献类型：期刊论文
| 作者 | Wu, Yong1,3; Hua, Chao1; Li, Wangliang2; Li, Qiang2,3; Gao, Hongshuai1,3; Liu, Huizhou1 |
| 刊名 | JOURNAL OF MEMBRANE SCIENCE
 |
| 出版日期 | 2009-02-20 |
| 卷号 | 328期号:1-2页码:219-227 |
| 关键词 | Ceramic membrane reactor Incorporation model Micromixing time Turbulence promoters |
| ISSN号 | 0376-7388 |
| 通讯作者 | Liu, HZ |
| 英文摘要 | Micromixing efficiency in a ceramic membrane reactor (CMR) by using turbulence promoters was studied with iodide-iodate test reaction. The existing incorporation model did not take into account concentration gradient. To elucidate the micromixing efficiency, a new incorporation model coupled with a continuous stirred tank reactor (CSTR) in series model was established to determine the ratio of micromixing time (t(m)) to segregation index (X(S)). The ratio of t(m) to X(S) can be affected significantly by low flux ratio. Based on the ratio, the experimental results indicated that membrane pore diameter has significant influence on micromixing efficiency at high superficial Reynolds number (Re(S)) under the same transmembrane pressure drop. However, the micromixing efficiency changed slightly at low Res. in addition, increasing permeation flow rates and bulk flow rates or decreasing membrane pore sizes could enhance micromixing efficiency. The introduction of turbulence promoters can further intensify the micromixing efficiency of the reactor. The micromixing efficiency of CMR with turbulence promoters was observed in a sequence of entry tube |
| WOS标题词 | Science & Technology ; Technology ; Physical Sciences |
| 类目[WOS] | Engineering, Chemical ; Polymer Science |
| 研究领域[WOS] | Engineering ; Polymer Science |
| 关键词[WOS] | ENERGY-DISSIPATION RATES ; IODATE REACTION SYSTEM ; FAST CHEMICAL-REACTION ; MASS-TRANSFER ; FLOW ; MICROFILTRATION ; ENHANCEMENT ; PERFORMANCE ; CONTACTORS ; SIMULATION |
| 收录类别 | SCI |
| 语种 | 英语 |
| WOS记录号 | WOS:000263891600026 |
| 公开日期 | 2013-12-10 |
| 版本 | 出版稿 |
| 源URL | [http://ir.ipe.ac.cn/handle/122111/6722]  |
| 专题 | 过程工程研究所_湿法冶金清洁生产技术国家工程实验室 |
| 作者单位 | 1.Chinese Acad Sci, Inst Proc Engn, Key Lab Green Proc & Engn, Beijing 100190, Peoples R China 2.Chinese Acad Sci, Inst Proc Engn, Natl Key Lab Biochem Engn, Beijing 100190, Peoples R China 3.Chinese Acad Sci, Grad Univ, Beijing 100049, Peoples R China |
| 推荐引用方式 GB/T 7714 | Wu, Yong,Hua, Chao,Li, Wangliang,et al. Intensification of micromixing efficiency in a ceramic membrane reactor with turbulence promoter[J]. JOURNAL OF MEMBRANE SCIENCE,2009,328(1-2):219-227. |
| APA | Wu, Yong,Hua, Chao,Li, Wangliang,Li, Qiang,Gao, Hongshuai,&Liu, Huizhou.(2009).Intensification of micromixing efficiency in a ceramic membrane reactor with turbulence promoter.JOURNAL OF MEMBRANE SCIENCE,328(1-2),219-227. |
| MLA | Wu, Yong,et al."Intensification of micromixing efficiency in a ceramic membrane reactor with turbulence promoter".JOURNAL OF MEMBRANE SCIENCE 328.1-2(2009):219-227. |
入库方式： OAI收割
来源：过程工程研究所
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。