Hydrogen production from steam reforming of glycerol by Ni-Mg-Al based catalysts in a fixed-bed reactor
文献类型：期刊论文
| 作者 | Wang, Chao1; Dou, Binlin1; Chen, Haisheng2; Song, Yongchen1; Xu, Yujie2; Du, Xu1; Luo, Tingting1; Tan, Chunqing2 |
| 刊名 | CHEMICAL ENGINEERING JOURNAL
 |
| 出版日期 | 2013-03-15 |
| 卷号 | 220页码:133-142 |
| 关键词 | Catalytic steam reforming Glycerol H-2 Ni-Mg-Al based catalysts |
| 英文摘要 | About 10 wt.% of glycerol can be produced during the conversion of vegetable oils or animal fats into biodiesel fuel by the transesterification process. To make use of glycerol and increase its values, H-2 production from catalytic steam reforming of glycerol by Ni-Mg-Al based catalysts was evaluated experimentally in a fixed-bed reactor under atmospheric pressure within a temperature range of 450-650 degrees C. The thermodynamic analysis was conducted by using a non-stoichiometric methodology based on the minimization of Gibbs free energy. The Ni-Mg-Al based catalysts were synthesized by the co-precipitation method with rising pH technique. The synthesized catalysts were characterized by the elemental analysis, BET, XRD and SEM methods. All the metals in the catalyst remained in oxide forms and the catalysts had the specific surface areas from 98.542 to 126.777 m(2)/g for different compositions. The results showed that glycerol conversion and H-2 selectivity were increased with increasing temperatures from 450 to 650 degrees C. The formations of CH4 and CO in the glycerol steam reforming were almost negligible. Carbon formation in glycerol steam reforming was serious in low temperatures. The catalyst containing NiO of 24.1 wt.%, MgO of 26.1 wt.% and Al2O3 of 49.8 wt.% performed appreciable catalytic activity, and the H-2 selectivity was found to be 78.5% and conversion of glycerol was up to 88.0% at 650 degrees C. The effects of the operating conditions including temperature, the ratio of steam to carbon (S/C), glycerol inlet concentration and flow rate of carrier gas on glycerol steam reforming by the optimized catalyst were tested. Based on a kinetic model assuming the power law with a first reaction order, the activation energy and the frequency factor for glycerol steam reforming by the Ni-Mg-Al based catalysts were calculated. (C) 2013 Elsevier B.V. All rights reserved. |
| WOS标题词 | Science & Technology ; Technology |
| 类目[WOS] | Engineering, Environmental ; Engineering, Chemical |
| 研究领域[WOS] | Engineering |
| 关键词[WOS] | CRUDE GLYCEROL ; FUEL-CELL ; ADSORPTION ; PYROLYSIS ; METHANOL ; KINETICS ; SORPTION ; ETHANOL ; COPPER ; GAS |
| 收录类别 | SCI |
| 语种 | 英语 |
| WOS记录号 | WOS:000317541200017 |
| 公开日期 | 2015-12-22 |
| 源URL | [http://ir.etp.ac.cn/handle/311046/98860]  |
| 专题 | 工程热物理研究所_中国科学院工程热物理所（论文库）_期刊论文（SCI） |
| 作者单位 | 1.Dalian Univ Technol, Minist Educ, Sch Energy & Power Engn, Key Lab Ocean Energy Utilizat & Energy Conservat, Dalian 116023, Peoples R China 2.Chinese Acad Sci, Inst Engn Thermophys, Beijing 100190, Peoples R China |
| 推荐引用方式 GB/T 7714 | Wang, Chao,Dou, Binlin,Chen, Haisheng,et al. Hydrogen production from steam reforming of glycerol by Ni-Mg-Al based catalysts in a fixed-bed reactor[J]. CHEMICAL ENGINEERING JOURNAL,2013,220:133-142. |
| APA | Wang, Chao.,Dou, Binlin.,Chen, Haisheng.,Song, Yongchen.,Xu, Yujie.,...&Tan, Chunqing.(2013).Hydrogen production from steam reforming of glycerol by Ni-Mg-Al based catalysts in a fixed-bed reactor.CHEMICAL ENGINEERING JOURNAL,220,133-142. |
| MLA | Wang, Chao,et al."Hydrogen production from steam reforming of glycerol by Ni-Mg-Al based catalysts in a fixed-bed reactor".CHEMICAL ENGINEERING JOURNAL 220(2013):133-142. |
入库方式： OAI收割
来源：工程热物理研究所
浏览0
下载0
收藏0
其他版本
除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。